Author Topic: Replacement of Yamaha Power Head Anodes  (Read 41040 times)

Offline Fishin Dude

  • Super Hero Member
  • *****
  • Posts: 4524
  • Karma: +0/-0
  • FISH CONTROL MY BRAIN
Replacement of Yamaha Power Head Anodes
« on: November 30, 2008, 10:14:30 AM »
After checking the power head anodes in my 2002 Yamaha F200, I decided it was necessary to replace them, and wish I had done so when I purchased the boat last November.I was soo busy doing other things to the boat, I overlooked this important item.

First, I removed the negative battery cable, then the spark plug cover from the rear of the powerhead. Then I loosened the anode cover bolt, (this is the one with the arrow in the photo). Do Not remove the bolt in the center of the cover, which is the one that attaches the anode to the cover, the anode can fall into the power head and take hours to take the motor apart to remove. Then remove the cover from the cylinder head.

Use a wire brush to clean the anode hole. Now you can remove the anode attachment bolt from the cover and remove the anode. Again, use a wire brush to clean the corrosion from the cover. You can use the wire brush to clean the anode and reuse it if you wish, as long as it's not worn down too much, but I recommend just replacing them (they are only about $10 each).

Attach the clean/new anode back onto the cover and slide a new rubber grommet over the anode and flush against the cover. Apply a light coat of grease to the grommet and then put the anode assembly back into the cylinder head hole. Line up the bolt hole, and install the bolt and tighten to torque specs.

After all anodes are cleaned/replaced, run the motor and check for leaks. No leaks, great. Reinstall the spark plug cover and cowling, your done. <'((((><
I've spent most of my life fishing, the rest I've just wasted     <'((((><


Offline IrishAyes

  • Fishing At It's Finest
  • Admin
  • Super Hero Member
  • *****
  • Posts: 17408
  • Karma: +0/-0
Re: Replacement of Yamaha Power Head Anodes
« Reply #1 on: November 30, 2008, 10:39:59 AM »
Thanks for the info FD. I didn't even realize there was an anode there. Silly me. Will have to check my F225 for it, and others.  ;D
Captain Joe of the Irish Ayes

May the holes in your net be no larger than the fish in it.  ~Irish Blessing


Online Hotrod

  • Administrator
  • Super Hero Member
  • *****
  • Posts: 20989
  • Karma: +0/-0
  • The Phyllis Ann
    • NJ Outdoords Media
Re: Replacement of Yamaha Power Head Anodes
« Reply #2 on: November 30, 2008, 11:30:25 AM »
Great info t^



Offline Fishin Dude

  • Super Hero Member
  • *****
  • Posts: 4524
  • Karma: +0/-0
  • FISH CONTROL MY BRAIN
Re: Replacement of Yamaha Power Head Anodes
« Reply #3 on: November 30, 2008, 12:44:49 PM »
Joe, there is 4 power head anodes on the F200, I'm sure it's the same on the 225. <'((((><
I've spent most of my life fishing, the rest I've just wasted     <'((((><


Offline IrishAyes

  • Fishing At It's Finest
  • Admin
  • Super Hero Member
  • *****
  • Posts: 17408
  • Karma: +0/-0
Re: Replacement of Yamaha Power Head Anodes
« Reply #4 on: November 30, 2008, 01:09:37 PM »
Thanks Darren, I will have to locate and replace them during the spring commissioning.  t^
Captain Joe of the Irish Ayes

May the holes in your net be no larger than the fish in it.  ~Irish Blessing

Offline Reckless

  • AKA Frankeu
  • Super Hero Member
  • *****
  • Posts: 2734
  • Karma: +0/-0
Re: Replacement of Yamaha Power Head Anodes
« Reply #5 on: January 22, 2009, 05:45:55 PM »
 I will have to check see if the 150 has them also. Thanks  grtn

Offline Fishin Dude

  • Super Hero Member
  • *****
  • Posts: 4524
  • Karma: +0/-0
  • FISH CONTROL MY BRAIN
Re: Replacement of Yamaha Power Head Anodes
« Reply #6 on: January 23, 2009, 11:02:11 PM »
Yep, they should be there.  <'((((><
I've spent most of my life fishing, the rest I've just wasted     <'((((><


Offline Reckless

  • AKA Frankeu
  • Super Hero Member
  • *****
  • Posts: 2734
  • Karma: +0/-0
Re: Replacement of Yamaha Power Head Anodes
« Reply #7 on: January 27, 2009, 04:47:23 AM »
 150 doesnt have ones that are easily replaced. They are under the heads. There are 8 of them but heads have to be removed to replace them.

Offline Stray Cat

  • Sr. Member
  • ***
  • Posts: 257
  • Karma: +0/-0
Re: Replacement of Yamaha Power Head Anodes
« Reply #8 on: January 27, 2009, 06:04:35 PM »
Good info, thanks. I have them too on my zukes in the same area. I don't think my owners manual shows them, but the service manual does.
« Last Edit: January 27, 2009, 06:06:18 PM by Stray Cat »
Mark


Offline Fishin Dude

  • Super Hero Member
  • *****
  • Posts: 4524
  • Karma: +0/-0
  • FISH CONTROL MY BRAIN
Re: Replacement of Yamaha Power Head Anodes
« Reply #9 on: January 27, 2009, 06:45:46 PM »
150 doesnt have ones that are easily replaced. They are under the heads. There are 8 of them but heads have to be removed to replace them.
Holy  crap ! Sounds like a major pain in the A$$.  <'((((><
I've spent most of my life fishing, the rest I've just wasted     <'((((><

Offline Vinnym

  • Full Member
  • **
  • Posts: 201
  • Karma: +0/-0
    • Morning Dew Sportfishing
Re: Replacement of Yamaha Power Head Anodes
« Reply #10 on: January 28, 2009, 08:28:10 AM »
This is good info. Thanks. How often do the anodes need to be changed?  5hrug Fishin Dude you have a 2002, is this the first time they are being changed?
Morning Dew Sport Fishing
Perth Amboy

Tight Lines & Calm Seas

Offline Fishin Dude

  • Super Hero Member
  • *****
  • Posts: 4524
  • Karma: +0/-0
  • FISH CONTROL MY BRAIN
Re: Replacement of Yamaha Power Head Anodes
« Reply #11 on: January 28, 2009, 12:45:10 PM »
This is good info. Thanks. How often do the anodes need to be changed?  5hrug Fishin Dude you have a 2002, is this the first time they are being changed?
I purchased this boat with the 2003 Yami on it last year. At the end of the season I decided to pull them have a look see. I wish I would have done it sooner, but was doing other things to the boat and this slipped my mind.  As you can see the condition required replacement.  Now I will always check them at the end of every season. I have no way of knowing if they were ever changed prior this. 5hrug  <'((((><
« Last Edit: January 29, 2009, 10:35:36 AM by Fishin Dude »
I've spent most of my life fishing, the rest I've just wasted     <'((((><

 

NJSFlogofinal1

BSX

terrafin

Heavy Duty truck Parts On Line

Web Site Design

JSBSE_430x80.png

Know Before You Go

Local Weather | Marine Bouy Weather | Inshore Forecast | Offshore Forecast | Interactive Wind Charts | Tide Charts | Sea Surface Temps | Chlorophyll Concentrates | Online Chart Viewer

-

new jersey marine weather forecastterrafin

-